Faculty Publications
Permanent URI for this communityhttps://idr.nitk.ac.in/handle/123456789/18736
Publications by NITK Faculty
Browse
15 results
Search Results
Item The effect of substrate temperature on the structural, optical and electrical properties of vacuum deposited ZnTe thin films(2009) Rao, G.K.; Bangera, K.V.; Shivakumar, G.K.The present paper reports the effect of substrate temperature on the structural, optical and electrical properties of vacuum deposited zinc telluride (ZnTe) thin films. X-ray diffraction (XRD) analysis of the films, deposited on glass substrates, revealed that they have cubic structure with strong (111) texture. Room temperature deposits are tellurium rich and an increase in the substrate temperature up to 553 °K results in stoichiometric films. Electrical conductivity has been observed to increase with the increase in substrate temperature, accompanied by increase in the carrier concentration and the mobility of the carriers. The optical bandgap energy and the thermal activation energy of the films have also been evaluated. © 2009 Elsevier Ltd. All rights reserved.Item Preparation and characterization of CdxZn1-xS thin films by spray pyrolysis technique for photovoltaic applications(2009) Raviprakash, Y.; Bangera, K.V.; Shivakumar, G.K.CdxZn(1-x)S (x = 0, 0.2, 0.4, 0.6, 0.8, and 1) thin films were deposited by the chemical spray pyrolysis technique using a less used combination of chemicals. Depositions were done at 573 K on cleaned glass substrates. The composition, surface morphology and structural properties of deposited films were studied using EDAX, SEM and X-ray diffraction technique. XRD studies reveal that all the films are crystalline with hexagonal (wurtzite) structure and inclusion of Cd into the structure of ZnS improved the crystallinity of the films. In the entire compositions, the (0 0 2) diffraction peak is prominent which gives lattice matching to the chalcogenide semiconductor such as CuInxGa1-xSe2 and CuIn (s1-xSex)2, which are used in photovoltaic devices. The value of lattice constant 'a' and 'c' have been observed to vary with composition from 0.382 to 0.415 nm and 0.625 to 0.675 nm, respectively. The band gap of the thin films varied from 3.32 to 2.41 eV as composition varied from x = 0.0 to 1.0. It was observed that presence of small amount of cadmium results in marked changes in the optical band gap of ZnS. © 2009 Elsevier Ltd. All rights reserved.Item Growth, structural and optical properties of CdxZn1-xS thin films deposited using spray pyrolysis technique(2010) Raviprakash, Y.; Bangera, K.V.; Shivakumar, G.K.CdxZn(1-x)S (x = 0, 0.2, 0.4, 0.6, 0.8, and 1) thin films were deposited by the chemical spray pyrolysis technique using a less used combination of chemicals. Depositions were done at 573 K on cleaned glass substrates. The composition, surface morphology and structural properties of deposited films were studied using EDAX, SEM and X-ray diffraction technique. XRD studies reveal that all the films are crystalline with hexagonal (wurtzite) structure and inclusion of Cd into the structure of ZnS improved the crystallinity of the films. The value of lattice constant 'a' and 'c' have been observed to vary with composition from 0.382 to 0.415 nm and 0.625 to 0.675 nm, respectively. The band gap of the thin films varied from 3.32 to 2.41 eV as composition varied from x = 0.0-1.0. It was observed that presence of small amount of cadmium results in marked changes in the optical band gap of ZnS. © 2009 Elsevier B.V. All rights reserved.Item Growth and thermal studies on pure ADP, KDP and mixed K 1-x(NH4)xH2PO4 crystals(2010) Shenoy, P.; Bangera, K.V.; Shivakumar, G.K.The investigations on the formation of mixed crystals of ammonium dihydrogen orthophosphate (ADP) and potassium dihydrogen orthophosphate (KDP) i.e. potassium ammonium dihydrogen phosphate, K1-x(NH 4)xH2PO4 have been presented in this paper. Pure and mixed crystals of ADP and KDP have been grown by slow evaporation technique from the supersaturated solution at an ambient temperature 26±1 °C for ammonium concentration x in the range 0.0 ? × ? 1.0 in the case of mixed crystals. Crystal compositions were determined by flame atomic absorption spectroscopy and chemical analysis. The results of the X-ray analysis of the grown crystals are also reported. Thermogravimetric analysis (TGA) and differential thermal analysis (DTA) were used to study the kinetic process of dehydration and the high temperature phase behaviour. DTA showed the distinct thermal events attributed to dehydration of ADP, KDP and K1-x(NH4)xH2PO4. The results of thermal analysis and chemical analysis are consistent with each other. © 2010 WILEY-VCH Verlag GmbH & Co. KGaA, Weinheim.Item The p-type doping of vacuum deposited ZnTe thin films with bismuth by a new technique of using nano-spheres(Elsevier Ltd, 2010) Rao, K.G.; Shivakumar, G.K.; Kasturi, V.B.The present paper reports the successful doping of vacuum evaporated zinc telluride (ZnTe) thin films with bismuth by a new technique of using nano-spheres. The discontinuous films of bismuth (the dopant material), containing bismuth in the form of nano-spheres, were prepared by vacuum evaporation and the ZnTe films were then deposited on top of them. The scanning electron microscopy (SEM) and X-ray diffraction (XRD) techniques were used to ascertain the formation of discontinuous bismuth films and the proper diffusion of bismuth in ZnTe films, respectively. After doping, the carrier concentration of the ZnTe films was found to increase by an order of the magnitude. The electrical conductivity also improved significantly. The photoconductivity and photo-response properties of the doped films were also analysed. © 2010 Elsevier B.V. All rights reserved.Item Properties of ZnO:Bi thin films prepared by spray pyrolysis technique(Elsevier Ltd, 2013) Sadananda Kumar, N.; Bangera, K.V.; Anandan, C.; Shivakumar, G.K.Undoped and Bi doped zinc oxide thin films were deposited on glass substrate at 450 °C using spray pyrolysis technique. The X-ray diffraction studies shows that Bi doped ZnO films are polycrystalline hexagonal structure with a preferred orientation along (101) direction. Crystallites size of the films decreases with increasing doping concentration. Scanning electron microscope image shows change in the surface morphology. The composition of Zn, O and Bi elements in the undoped and Bi doped ZnO films were investigated by X-ray photoelectron spectroscopy. Bi doped ZnO thin films show a transparency nearly 75% in the visible region. The optical band gap of ZnO thin films reduces from 3.25 eV to 3.12 eV with an increase in Bi concentration from 0 to 5at.% respectively. Electrical conductivity of ZnO thin films increased from 0.156 to 6.02S/cm with increasing Bi dopant concentration from 0% to 5% respectively. © 2013 Elsevier B.V. All rights reserved.Item Effect of substrate temperature and film thickness on the thermoelectric properties of In2Te3 thin films(Elsevier Ltd, 2017) Vallem, V.; Bangera, K.V.; Shivakumar, G.K.Herein, the thermoelectric properties of vacuum deposited In2Te3 thin films were investigated by varying the substrate temperature and the thickness of the films. The thermo-electro motive force of the prepared films was found to increase with an increase in the substrate temperature up to 423 K and then decrease at 473 K due to the presence of mixed-phase structure. The maximum thermoelectric power of 220 ?V/K was observed for the films deposited at 423 K substrate temperature, which was found to decrease with increase in thickness. The films deposited at 423 K with 150 nm thickness showed maximum power factor of 27 ?Wm?1K?2 at 450 K. These observations are explained on the basis of structural, morphological and compositional changes. © 2017 Elsevier B.V.Item Band gap engineering of mixed Cd(1?x)Zn(x)Se thin films(Elsevier Ltd, 2017) Santhosh, T.C.M.; Bangera, K.V.; Shivakumar, G.K.This paper deals with band gap engineering in CdZnSe thin films. This was achieved by adding different amounts of zinc selenide (ZnSe) to cadmium selenide (CdSe). The weight percentage of ZnSe (x) was varied from 0 to 1 in steps of 0.2. The films were prepared using thermal evaporation technique. The structural analysis was carried out using X-ray diffraction. Surface morphology and elemental composition of the grown films was investigated using scanning electron microscopy (SEM) and energy dispersive spectroscopy (EDS) respectively. As deposited cadmium selenide thin films were dark reddish in color, changes to lemon-yellow with increase in ZnSe concentration. Electrical transport studies have been carried out using two probe method. Resistivity of the mixed films increased with increase in ZnSe concentration and it shows semiconducting behavior. It is observed that activation energy for conduction increases from 0.39 eV to 0.85 eV with increase in ZnSe concentration. Optical properties of the films were analyzed from absorption and transmittance studies. It is observed that the optical band gap increases gradually from 1.67 eV to 2.60 eV as ‘x’ varied from 0 to 1. © 2017 Elsevier B.V.Item Properties of CdxZn1-xO thin films and their enhanced gas sensing performance(Elsevier Ltd, 2017) Bharath, S.P.; Bangera, K.V.; Shivakumar, G.K.CdxZn1-xO(0 ? x ? 0.20) thin films with different Cd concentrations were successfully deposited on glass substrate using spray pyrolysis technique. X-ray diffraction (XRD), scanning electron microscope (SEM) and energy dispersive X-ray analysis (EDAX) were used for structural, surface morphological and compositional characterization. The XRD analysis revealed that the synthesized films were hexagonal in structure with (002) orientation. The SEM studies confirm the formation of homogeneous and uniform films. Optical transmittance and electrical conductivity of the films were evaluated using UV–Visible spectroscopy and two probe method respectively. The optical studies showed that the CdxZn1-xO thin films have optical transmittance in entire visible region. The resistivity of undoped films were very high and it decreases with addition of cadmium. The gas sensing properties were investigated at optimal temperature of 350 °C for various volatile organic compounds like acetone, ethanol and methanol. The CdxZn1-xO thin films with 10 at. % cadmium concentration showed the sensitivity of 50% for 1 ppm ethanol. © 2017 Elsevier B.V.Item Synthesis and band gap tuning in CdSe(1-x)Te(x) thin films for solar cell applications(Elsevier Ltd, 2017) Santhosh, T.C.M.; Bangera, K.V.; Shivakumar, G.K.Thin films of CdSe(1-x)Te(x) (x = 0 – 1) were grown on to the glass substrates by thermal evaporation method (PVD). The effect of annealing duration on the formation of single phase ternary alloys were systematically investigated. The prepared thin films were characterized by using FE-SEM, EDS and X-ray diffractometer. The X-ray diffraction studies shows that vacuum annealed films are polycrystalline in nature, and well oriented along a preferred direction of (0 0 2) for hexagonal and along (1 1 1) for cubic crystal structure. It is observed that increase in the CdTe concentration leads to change in the crystal structure from hexagonal to cubic. The absorption coefficients and optical band gaps were evaluated from spectrometric measurements. It is observed that optical band gap can be tuned from 1.67 eV to 1.51 eV as value of x varied from 0 to 1. © 2017 Elsevier Ltd