Faculty Publications
Permanent URI for this communityhttps://idr.nitk.ac.in/handle/123456789/18736
Publications by NITK Faculty
Browse
5 results
Search Results
Item Experimental investigation of esters of mahua oil as an alternative fuel for dual fuel engine(2008) Reddy, P.B.; Kapilan, N.; Reddy, R.P.In the present work, an attempt was made to use methyl ester of mahua oil (MEMO) as substitute for dieselin dual fuel engine. A four stroke single cylinder engine was modified to work in dual fuel mode. From the test results, it was observed that the MEMO could be used as pilot fuel in dual fuel engine. At lower loads, diesel gave higher brake thermal efficiency. But at higher loads, biodiesel resulted in brake thermal efficiency comparable with diesel and lower smoke and oxides of nitrogen emissions. From the test results, it was concluded that MEMO could be used as a substitute for diesel in dual fuel engine.Item Characterization and effect of using Mahua oil biodiesel as fuel in compression ignition engine(2009) Kapilan, N.; Ashok Babu, T.P.; Reddy, R.P.There is an increasing interest in India, to search for suitable alternative fuels that are environment friendly. This led to the choice of Mahua Oil (MO) as one of the main alternative fuels to diesel. In this investigation, Mahua Oil Biodiesel (MOB) and its blend with diesel were used as fuel in a single cylinder, direct injection and compression ignition engine. The MOB was prepared from MO by transesterification using methanol and potassium hydroxide. The fuel properties of MOB are close to the diesel and confirm to the ASTM standards. From the engine test analysis, it was observed that the MOB, B5 and B20 blend results in lower CO, HC and smoke emissions as compared to diesel. But the B5 and B20 blends results in higher efficiency as compared to MOB. Hence MOB or blends of MOB and diesel (B5 or B20) can be used as a substitute for diesel in diesel engines used in transportation as well as in the agriculture sector. © 2009 Science Press, Institute of Engineering Thermophysics, CAS and Springer Berlin Heidelberg.Item Effect of using Mahua as an alternative fuel in diesel engine(2009) Kapilan, N.; Ashok Babu, T.P.A.; Reddy, R.P.There is an increasing interest in India, to search for suitable alternative fuels that are environment friendly. This led to the choice of non-edible Mahua Oil (MO) as one of the main alternative fuels to diesel oil in India. The objective of the present work is to use MO as a partial renewable alternative substitute for diesel in the agricultural diesel engine. Since the viscosity of the MO is high, it was blended with conventional diesel oil in various proportions (M5, M10, M15 and M20 on volume basis) and fuel properties of the blends were determined and compared with the diesel. Engine tests were carried out on a single cylinder diesel engine at varying loads (0%, 25%, 50%, 75% and 100%), without making any modification in the fuel injection system and the results were compared with the diesel. The M5 and M10 blends resulted in performance and emission characteristics comparable to diesel operation and also emits lower carbon monoxide, hydrocarbon and smoke emissions as compared to other blends. From the analysis, it is concluded that the MO can be partially substituted for diesel oil in the diesel engine, without making any modification in the hardware of the engine.Item Performance characteristics of a dual fuel engine operated with Mahua biodiesel and liquefied petroleum gas(ASTM International, 2011) Kapilan, N.; Ashok Babu, T.P.; Reddy, R.P.Fuel crisis because of dramatic increase in vehicular population and environmental concerns have renewed the interest of the scientific community to look for alternative fuels of bio-origin such as vegetable oils and ethanol. India is looking at biodiesel derived from Mahua oil (MO), as one of the renewable alternative fuels for compression ignition (CI) engine. Although MO biodiesel (MOB) has several advantages over fossil diesel, in the present scenario, the use of biodiesel is restricted due to its high cost. In India, liquefied petroleum gas (LPG) is easily available and is one of the cheapest gaseous fuels. Hence, use of LPG to fuel a CI engine along with MOB seems to be an option for substitution of fossil diesel. In the present work, LPG, which was fumigated along with the air and biodiesel was admitted into the engine cylinder through conventional fueling device as an igniter. A single cylinder CI engine was modified to work in dual fuel mode and engine tests were carried out at rated speed under variable load conditions. The performance of the engine in dual fuel mode was compared with the diesel. The dual fuel operation results in thermal efficiency close to the diesel and also reduces the NOx and smoke emissions significantly. From the experimental results, we concluded that biodiesel in dual fuel mode with cheaper gaseous fuel induction is an option for reducing the operating cost of the biodiesel fuelled CI engine. Copyright ©2011 by ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959.Item Performance characteristics of a dual fuel engine operatedwith mahua biodiesel and liquefied petroleum gas(2011) Kapilan, N.; Ashok Babu, T.P.A.; Reddy, R.P.Fuel crisis because of dramatic increase in vehicular population and environmental concerns have renewed the interest of the scientific community to look for alternative fuels of bio-origin such as vegetable oils and ethanol. India is looking at biodiesel derived from Mahua oil (MO), as one of the renewable alternative fuels for compression ignition (CI) engine. Although MO biodiesel (MOB) has several advantages over fossil diesel, in the present scenario, the use of biodiesel is restricted due to its high cost. In India, liquefied petroleum gas (LPG) is easily available and is one of the cheapest gaseous fuels. Hence, use of LPG to fuel a CI engine along with MOB seems to be an option for substitution of fossil diesel. In the present work, LPG, which was fumigated along with the air and biodiesel was admitted into the engine cylinder through conventional fueling device as an igniter. A single cylinder CI engine was modified to work in dual fuel mode and engine tests were carried out at rated speed under variable load conditions. The performance of the engine in dual fuel mode was compared with the diesel. The dual fuel operation results in thermal efficiency close to the diesel and also reduces the NOx and smoke emissions significantly. From the experimental results, we concluded that biodiesel in dual fuel mode with cheaper gaseous fuel induction is an option for reducing the operating cost of the biodiesel fuelled CI engine. Copyright © 2011 by ASTM International.